Additinal Electrical Fan

lmmr74 · 08-10-2011, 09:50 PM

Thanks for the tip. But if i keep the mechanical fan plus the reversed electric fan on the front of the radiator, will i get an extra cooling efect? Will it avoid the engine to overheat on heavy traffic?

Thks again in advance for the help!

Greetings from Lisbon!

907mge · 08-11-2011, 12:17 AM

I have had my supra in traffic on hot days with the ac on and have not had any overheating problems. If you are having a problem with overheating you most likely have a problem causing it. The supra is a modern car and was deigned from factory to be a daily driver. Also electric fans are a power gain only when the electric fan is not running since it will just transfer the load to the alternator.

El Supracabras · 08-11-2011, 03:41 AM

The stock fan is sufficient on the GTE if the clutch is good and you at least use the shroud. There are all types of electric fan options if that's the route you want to go. There are ready to bolt in kits that cost some coin, some universal kits that cost less but require some driveway engineering to fit and there is the junk yard route. Measure your radiator and its clearances then go to the junk yard and find one that fits.
As mentioned before, if you are overheating in traffic there is likely something wrong with the cooling system. The time and money would be better spent checking the condition of the cooling system components before replacing the fan set up.

cre · 08-11-2011, 07:06 AM

I agree with the others that the stock fan should be more than sufficient. However, do note that the GTE already has a supplimental electric fan mounted between the radiator and a/c condenser.... not including the one or two small aux fans next to the mechanical fan. If your car is GTE and the A/C fan is still in place you could bypass it's relay so that it's on full time, but you're wasting energy doing to... the greater the electric draw on the alternator the greater it's resistence and you lose more power.

Fix the real problem is what I recommend.

lmmr74 · 08-11-2011, 12:32 PM

Thank you all for your replies!

I am checking the entire cooling system, i changed the water pump, the thermostat valve, i will also check the radiator just to make sure it's not blocked or something. What other components should i check?

El Supracabras · 08-11-2011, 12:45 PM

All of the hoses. Make sure the system is completely purged of air, the fan clutch is good, the shroud is present, check for blockage between the radiator and a/c condenser also if front of the condenser. The 7MGTE cooling system is complex and has many points of potential failure but in good condition it is capable of handling some serious heat.

lmmr74 · 08-11-2011, 02:07 PM

Just one more thing...how can i check if the fan clutch is working fine??

08-10-2011, 09:50 PM	#1
lmmr74 Stock Join Date: Aug 2011 Location: Portugal Posts: 21	Additional electrical fan Thanks for the tip. But if i keep the mechanical fan plus the reversed electric fan on the front of the radiator, will i get an extra cooling efect? Will it avoid the engine to overheat on heavy traffic? Thks again in advance for the help! Greetings from Lisbon!

08-11-2011, 07:06 AM	#4
cre Toyota Racing Development Join Date: Apr 2007 Posts: 5,038	I agree with the others that the stock fan should be more than sufficient. However, do note that the GTE already has a supplimental electric fan mounted between the radiator and a/c condenser.... not including the one or two small aux fans next to the mechanical fan. If your car is GTE and the A/C fan is still in place you could bypass it's relay so that it's on full time, but you're wasting energy doing to... the greater the electric draw on the alternator the greater it's resistence and you lose more power. Fix the real problem is what I recommend. __________________ If something breaks or you need to contact a member of the administration please post HERE. Unless it's a private or administration matter please post it on the forum. It benefits no one else if car related questions aren't posted for future users and takes away from the time I'm able to spend helping on the rest of the forum. If you're so inclined I'm always more than happy to accept tips via PayPal. Tip Jar --->

08-11-2011, 12:45 PM	#6
El Supracabras 3" Exhaust Join Date: Feb 2010 Location: Chicago Posts: 240	All of the hoses. Make sure the system is completely purged of air, the fan clutch is good, the shroud is present, check for blockage between the radiator and a/c condenser also if front of the condenser. The 7MGTE cooling system is complex and has many points of potential failure but in good condition it is capable of handling some serious heat. Attached Thumbnails

Thread Tools
Show Printable Version Email this Page
Display Modes
Switch to Linear Mode Hybrid Mode Switch to Threaded Mode

Similar Threads
Thread	Thread Starter	Forum	Replies	Last Post
electrical problem! I think!!!!!help!!	Boostcrazy61	MKII Supra	0	08-21-2009 12:08 AM
Frustrating electrical problem	thebobfoster	Non-Generation Specific Questions	1	05-30-2009 09:16 PM
Needing some electrical help	happysupraowner:)	MKIII Supra	3	04-19-2009 01:16 AM
Oil Pressure...Mechanical or Electrical???	Luvs2slide	MKIII Supra	5	08-23-2006 12:42 AM
Intermittent Electrical Problems on a ’93 MKIV	gjs_cds	Shops & Part Reviews	0	05-22-2006 02:39 PM

08-11-2011, 12:17 AM	#2
907mge 20psi boost Join Date: Dec 2009 Location: Harrisburg Posts: 759	I have had my supra in traffic on hot days with the ac on and have not had any overheating problems. If you are having a problem with overheating you most likely have a problem causing it. The supra is a modern car and was deigned from factory to be a daily driver. Also electric fans are a power gain only when the electric fan is not running since it will just transfer the load to the alternator.

08-11-2011, 03:41 AM	#3
El Supracabras 3" Exhaust Join Date: Feb 2010 Location: Chicago Posts: 240	The stock fan is sufficient on the GTE if the clutch is good and you at least use the shroud. There are all types of electric fan options if that's the route you want to go. There are ready to bolt in kits that cost some coin, some universal kits that cost less but require some driveway engineering to fit and there is the junk yard route. Measure your radiator and its clearances then go to the junk yard and find one that fits. As mentioned before, if you are overheating in traffic there is likely something wrong with the cooling system. The time and money would be better spent checking the condition of the cooling system components before replacing the fan set up.

08-11-2011, 12:32 PM	#5
lmmr74 Stock Join Date: Aug 2011 Location: Portugal Posts: 21	Thank you all for your replies! I am checking the entire cooling system, i changed the water pump, the thermostat valve, i will also check the radiator just to make sure it's not blocked or something. What other components should i check?

08-11-2011, 02:07 PM	#7
lmmr74 Stock Join Date: Aug 2011 Location: Portugal Posts: 21	Just one more thing...how can i check if the fan clutch is working fine??