Replaced HG, still overheating???

Wileyk24 · 10-04-2012, 12:18 AM

Fan clutch is replaced, brand new unit. I will try to top it off and see if it bubbles at all. I am at a total loss here. Going to test my thermostat as well(which is new also).

Mishimoto · 10-04-2012, 02:21 PM

Hmm See what happens after removing air from the cooling system. Perhaps a wonky temperature sender is causing this?

Bill UK · 10-04-2012, 06:56 PM

Any increase in the level of the coolant expansion tank level when this happens ?

Wileyk24 · 10-06-2012, 02:47 PM

Bill I will check. I am working on the car this weekend, I remember how much was in there before it overheated, so I will see if there was any overflow.

What are you thinking?

Wileyk24 · 10-07-2012, 08:00 PM

Ok so no change in the radiator fluid level. The overflow bottle dipped slightly, less than an inch. The car is not overflowing coolant onto the ground either.

So today I decided to test the thermostat. I took it out, checked the bottom an it is a 195 degree tstat. I proceeded to boil it and with a thermometer found it wasn't opening until well after 200 degrees. Brand new unit, not functioning properly. So I went to autozone to get a new one and the system said I needed a 180 degree stat. So I bought it and took it home and boiled it. The new one open as it should and seemed to open easier than the last. Time to install.

I installed the new tstat, topped off all fluids and took her for a test drive. Good news, I made it a lot further than just one block. I actually drove all around town and on the highway. The car felt good, but my temperature gauge is settling at 3/4 the way up the temp gauge and staying there. Regardless of how I am driving.

So when the car is idling the temp gauge stays right in the middle. Once I start driving city or highway it goes up to 3/4 and stays there. Once it is up there it won't come down until I shut off the car, even at stop signs it stays up there. But once the car is off, I turn the key back on so the gauges are powered and the temp gauge sits at slightly under halfway which is perfect...

Anybody experience this before?

Wileyk24 · 10-10-2012, 01:00 AM

Still at a loss here. Went ahead and ordered new oem thermostat and temperature sensor from Toyota. Even though I had brand new autozone stuff in there already. Apparently if I can buy a thermostat brand new and have it not work, its possible the temp guage is acting up too.

I will replace both and post back my results. Still very open to ideas....

cre · 10-10-2012, 04:13 AM

Have you checked your ignition timing recently?

10-04-2012, 02:21 PM	#2
Mishimoto Stock Join Date: Jun 2012 Location: Wilmington, DE Posts: 5	Hmm See what happens after removing air from the cooling system. Perhaps a wonky temperature sender is causing this? __________________ John Marsteller Mishimoto Automotive

10-07-2012, 08:00 PM	#5
Wileyk24 Stock Join Date: Dec 2011 Location: Middletown, NY Posts: 27	Ok so no change in the radiator fluid level. The overflow bottle dipped slightly, less than an inch. The car is not overflowing coolant onto the ground either. So today I decided to test the thermostat. I took it out, checked the bottom an it is a 195 degree tstat. I proceeded to boil it and with a thermometer found it wasn't opening until well after 200 degrees. Brand new unit, not functioning properly. So I went to autozone to get a new one and the system said I needed a 180 degree stat. So I bought it and took it home and boiled it. The new one open as it should and seemed to open easier than the last. Time to install. I installed the new tstat, topped off all fluids and took her for a test drive. Good news, I made it a lot further than just one block. I actually drove all around town and on the highway. The car felt good, but my temperature gauge is settling at 3/4 the way up the temp gauge and staying there. Regardless of how I am driving. So when the car is idling the temp gauge stays right in the middle. Once I start driving city or highway it goes up to 3/4 and stays there. Once it is up there it won't come down until I shut off the car, even at stop signs it stays up there. But once the car is off, I turn the key back on so the gauges are powered and the temp gauge sits at slightly under halfway which is perfect... Anybody experience this before? Last edited by Wileyk24; 10-07-2012 at 08:04 PM.

10-10-2012, 04:13 AM	#7
cre Toyota Racing Development Join Date: Apr 2007 Posts: 5,038	Have you checked your ignition timing recently? __________________ If something breaks or you need to contact a member of the administration please post HERE. Unless it's a private or administration matter please post it on the forum. It benefits no one else if car related questions aren't posted for future users and takes away from the time I'm able to spend helping on the rest of the forum. If you're so inclined I'm always more than happy to accept tips via PayPal. Tip Jar --->

Similar Threads
Thread	Thread Starter	Forum	Replies	Last Post
Continued overheating, coolant spewing from radiator when warming up...	Da6onesupra	MKIII Supra	10	02-19-2011 05:42 AM
still overheating	quiky	MKIV Supra	1	07-17-2009 12:11 PM
supra newb overheating	vdesign	MKIII Supra	13	06-27-2008 05:09 PM
82 Supra overheating	suprahusker	MKII Supra	2	10-17-2007 01:59 AM
2 Questions: 1 About Overheating, 1 About HeadUnit Adaptor	V1P3R	MKIII Supra	9	07-17-2007 05:26 AM

10-04-2012, 12:18 AM	#1
Wileyk24 Stock Join Date: Dec 2011 Location: Middletown, NY Posts: 27	Fan clutch is replaced, brand new unit. I will try to top it off and see if it bubbles at all. I am at a total loss here. Going to test my thermostat as well(which is new also).

10-04-2012, 06:56 PM	#3
Bill UK AEM EMS Join Date: Jul 2006 Location: UK Posts: 891	Any increase in the level of the coolant expansion tank level when this happens ?

10-06-2012, 02:47 PM	#4
Wileyk24 Stock Join Date: Dec 2011 Location: Middletown, NY Posts: 27	Bill I will check. I am working on the car this weekend, I remember how much was in there before it overheated, so I will see if there was any overflow. What are you thinking?

10-10-2012, 01:00 AM	#6
Wileyk24 Stock Join Date: Dec 2011 Location: Middletown, NY Posts: 27	Still at a loss here. Went ahead and ordered new oem thermostat and temperature sensor from Toyota. Even though I had brand new autozone stuff in there already. Apparently if I can buy a thermostat brand new and have it not work, its possible the temp guage is acting up too. I will replace both and post back my results. Still very open to ideas....